Flotation Response of the Kindo Didaye Coal Deposit, Wolaita Zone
| dc.contributor.advisor | Mulugeta Sisay (PhD) | |
| dc.contributor.author | Temesgen Ayisa | |
| dc.date.accessioned | 2024-05-02T07:41:40Z | |
| dc.date.available | 2024-05-02T07:41:40Z | |
| dc.date.issued | 2023-06 | |
| dc.description.abstract | The main objective of the project was to investigate the optimum flotation behavior of the coal.Flotation is an important process, which involves removing ash, and other impurities from coal to improve its quality for energy and industrial use. Froth flotation is a widely used method for coal cleaning, which relies on the difference in surface properties between the coal particles and the mineral matter.However, the efficiency of froth flotation is greatly affected by the size of coal particles. The bulk sample from jaw crusher was milled by cross-bitter miller and coal sample was ready for separation in arranged sieve shakers based on their size. Then,fine powder coal samples were prepared by using different size of sieve shaker arranged as and measured the mass of the feeds of each particle size before the starting of flotation processes.In this study, four different sizes range of coal particles (-500 to +250 μm, -250 to +150 μm,-150 to +125 μm,-125μm to +75μm and -75 μm) were tested for their ability to float in the froth flotation process. Because of natural hydrophobicity of coal, there are a range of chemicals used to further enhance the floatability of coal particles.Results showed that the optimum flotation was highest for particle size und.75μm, while particles above +250μm showed the poorest performance and the same result was seen by the increase of kerosene amount at the same particle size. The results suggest that particle size and the over use of reagents are critical factors in the success of flotation response. The findings of this study will help in optimizing the coal cleaning by flotation increasing the heat value of the coal by avoiding the impurities. So in this flotation experiment the calorific value increases. | |
| dc.identifier.uri | https://etd.aau.edu.et/handle/123456789/2952 | |
| dc.language.iso | en_US | |
| dc.publisher | Addis Ababa University | |
| dc.subject | Coal | |
| dc.subject | Flotation response | |
| dc.subject | chemical reagents | |
| dc.subject | particle size | |
| dc.title | Flotation Response of the Kindo Didaye Coal Deposit, Wolaita Zone | |
| dc.type | Thesis |